Hello, everyone. In this issue, we are going to present a 13-year-old Volkswagen Tiguan SUV, which is also the first post-10 model we are currently preparing. "There is a way to go, but there is no cultivation" This is the slogan made by "Tiguan" in entering the domestic market for 10 years. It implies that this car can convey the realm of life with a spirit of thousands of miles and unlimited spans and enter the public. Vision. Of course, "No one is perfect, and no car is finished." So what are the defects of this car? You can follow me to find answers and solutions together.
The owner of the car should have contacted us in 19 years. Due to various trivial matters in the middle, he has been dragged to find us again now. Through chatting, I learned that the car owner is about to enter the marriage hall, hoping to take a break with his car before getting married. So I made an appointment with us a week before the construction and drove the car over as planned. However, because of the regional traffic control, they just caught up with the upper limit number, so they could only drive over at night.
After the car drove over, we conducted an inspection and road test on the whole car. It can be seen from the picture that the fog lamp frame has been damaged. Because this car had been partially painted up before, the sheet metal ash of the car body has also been cracked. And orange peel pattern is serious, except for the roof, the whole car is like this, the same door, under the side light, can come out three colors, the original plan is to solve the orange peel problem through mirror correction, but from now on According to the situation, the paint of the whole car must be re-painted.
The sunroof is leaking, causing the sun visor to be rusted and damaged. For problems like this, we have to deal with more than ten units every year. The following article will carry out detailed solutions and radical cures for skylight leakage.
Handle discoloration common problem
p0 The situation of
is probably like this,Next, we will carry out restoration work on this car.
Remove the seat, because the sunroof leaks, the carpet has begun to mold, and there will be a musty smell when the air conditioner is turned on. If this takes a long time, you will really be unable to stand it
Remove the interior trim panel and the roof
This is the interface that causes the skylight to leak. The two pipes are rigidly connected. As long as the angle is slightly wrong, water leakage will occur. There are 8 interfaces in the whole car like this, 4 of which are on the four corners of the sunroof, and the remaining 4 are on both sides of the front instrument panel and on both sides of the trunk.
These are the four pipes on the roof (the four corners of the sunroof are blue). The picture can be zoomed in to see the clear point
This is the connection point of the front dashboard ( The black round hole is also the easiest place to fall off.
There is a rubber water outlet at the junction of the instrument panel and the trunk. This design is really incomprehensible, because once there is mud or other debris in the pipeline, it is easy to cause blockage or obstruction , So that the water in the pipeline accumulates more and more, cannot be discharged, and finally enters the ceiling and the floor glue from the top of the interface and the skylight.
So our solution is to change and strengthen the original car pipeline. First, change the water outlet rubber port and cut off the part that is most likely to be blocked. And for the above-mentioned 8 joints, use chucks to reinforce them during installation. After the installation is completed, the skylight can leak water and completely kill it!
Due to water leakage from the skylight,As a result, the carpet gets damp, so we have done a lot of cleaning and high-temperature sterilization of the interior.
The interior and chassis should also be white.
Clean the disassembled parts from the car, and pick out the worn and defective parts for repair.
The rear air outlet and ceiling light trim were severely damaged and beyond the scope of repair, so we replaced them.
The original sun visor has been damaged and replaced with a new one. However, the main driver's side was seriously out of stock in China, and it was scheduled for ten days to arrive. You must know that it is the most troublesome thing to find the source of the parts that cannot be repaired, so the moment you receive the goods, you feel beautiful. Because we have to complete the repair work of the whole vehicle within the specified time, and do not want to leave any regrets.
All the interiors have been cleaned up and dried in the sun
The carpet is also refreshed
img the old
3 replacement The original 187B host
Test the host after installation
start reinstalling
img26 pimg
img p3p img
img0
oil and water and accessories have all been arranged
img31 p3p
_p3 img p0 p3 img p0 p0 p3 img
0
p0 p3p
front face removal and replacement
Clean the removed parts,Reinstallation after rest
Filling with coolant
Adding coolant
3p
3p img_p0 Torque according to the standard during the installation process
During the replacement of the chassis parts, the dismantled parts were cleaned and lubricated
img41
half shaft Oil seal replacement
Fastening screws
Replace the dust cover
The rust of the wheel hub and the brake disc are integrated
The dismantled wheel hub has also been repaired and is as bright as new
img47p
prepare to apply BASF water-based parrot paint
spraying
3 pimg
img the final cleaning of the engine compartment pp0 img51 pimg
img
The whole vehicle is ready for construction for 18 days,Whenever this time, the inner world is always relieved and satisfied. "Relaxation" is because during the construction of each vehicle, my team and I must be highly concentrated to do the same thing, and work overtime until late every night, which is rare and easy. "Satisfaction" is because after the completion of each car, all the indicators have reached our expected results, and finally we can sit down, listen to the music, enjoy quietly, appreciate its lines and appreciate its beauty. Next, I will take everyone to see its final effect.
nacelle
machine cover
nacelle line
dipstick
intake pipe Road
generator
engine room trim
img3
187
img_img0
img62
Armrest box
Dome light
Handle
imgp65
img3p3p imgp3p img
img
img
3
img71p img
imgp3p img_
The repair work of this Tiguan 7 years ago is over here, thank you for watching, remember to pay attention! The rebirth of an old car will be updated from time to time, see you in the next issue!
To undertake: Taiyuan MHDS Car Club
.-
-
-
-
-
-
-
-
-
-
-
-
-
-
-
-
-
-
-
-
-
-